Coral Calcium Powder, MARINE BIO PRODUCTS

Coral Calcium Powder – [ STANDARDS ]

■ Specification

Name of Product: CCP-44 (Coral Calcium Powder 44 microns)

Analysis Specification
Color Grey-white or yellowish-brown
Calcium 34% or more
Magnesium 1.5% or more
Arsenic(as As) 3ppm or less
Lead 0.5ppm or less
Mercury 0.1ppm or less
Cadmium 1ppm or less
Pesticide residue *1 Undetectable
Particle Size 44μpass 90% or more
PCB Undetectable
Loss of Drying 1% or less
Microbiological Test Specification
General bacteria count 3×103/g or less
Yeast & Mold 1×102/g or less
Colibacillus Negative
Salmonella Negative
Enteritis vibrio Negative
Microbiological Test Specification
General bacteria count 3×103/g or less
Yeast & Mold 1×102/g or less
Colibacillus Negative
Salmonella Negative
Enteritis vibrio Negative

*1 Endrin, Dildrin, Aldorin, BHC, DDT

■ MATERIAL  SAFETY  DATA  SHEET

I.    PRODUCT IDENTIFICATION:

PRODUCT NAME……..:  NON-CALCINATED CORAL CALCIUM / Coral Calcium Powder
CHEMICAL NAME…….: Calcium Carbonate
CAS NUMBER……….: CAS #:   471-34-1
FORMULA………….: CaCO3

II.   COMPOSITION/INFORMATION ON INGREDIENTS

INGREDIENT NAME
Calcium Carbonate

CAS #:   471-34-1

III.  PHYSICAL PROPERTIES:

APPEARANCE……: Light Yellowish White
pH (100%)…………………..: 7.0-9.0
VISCOSITY……………..: Not Applicable
SOLUBILITY IN WATER ……: Insoluble
SPECIFIC GRAVITY ………: Not Established
BULK DENSITY…………..: About 1.3g/ml (44μm)
VAPOR PRESSURE ………..: Not Applicable
VAPOR DENSITY …………:Not Applicable (Air = 1)

IV.   FIRE AND EXPLOSION DATA:

FLASH POINT…………………:Not Applicable.
AUTO-IGNITION TEMPERATURE…….:Not Established

EXTINGUISHING MEDIA………….:Water Spray, Carbonic acid gas extinguisher

V.   EMERGENCY AND FIRST AID PROCEDURES:

FIRST AID FOR EYES……: In case of contact, don’t scratch.
Flush affected area with plenty of water.
If symptoms develop, seek medical advice

FIRST AID FOR SKIN……: In case of contact,
flush affected area with water.

FIRST AID FOR INHALATION: If inhaled, rinse
mouth and throat thoroughly with water.

FIRST AID FOR INGESTION.: If swallowed in large quantity,
washout mouth and vomit. If symptoms
develop, seek medical advice.

VI.   EMPLOYEE PROTECTION RECOMMENDATIONS:

EYE PROTECTION REQUIREMENTS……..:
Safety glasses or goggles.

SKIN PROTECTION REQUIREMENTS…….:
Gloves

RESPIRATOR REQUIREMENTS…………:
Mask

VENTILATION REQUIREMENTS………..:
Use local ventilation if dusting is a problem.

VII.  REACTIVITY DATA:

STABILITY………………: Stable under
ordinary conditions of use and storage.

HAZARDOUS POLYMERIZATION…: Will not occur.

VIII. SPILL AND LEAK PROCEDURES:

SPILL OR LEAK PROCEDURES….: Utilize
recommended protective clothing.  Clean
spills with mechanical tools and wash surface with water.

WASTE DISPOSAL METHOD…….: For disposal, contact
a properly licensed waste treatment, storage, disposal
or recycling facility. In case of in-house disposal,
incinerate or reclaim after confirmation of safety.

IX.   SPECIAL PRECAUTIONS & STORAGE DATA:

STORAGE TEMPERATURE(MIN/MAX): Ambient/Ambient.

SPECIAL SENSITIVITY………: None

HANDLING/STORAGE PRECAUTIONS:
In case of handling in large quantity,
Wearing protect clothing such as mask,
goggles, gloves)is recommendable.
Store in a cool and dry place away from direct
sunlight, heat and incompatible materials
(see Section VIII). Store away from
contamination and odor.

X.    SHIPPING INFORMATION:

Avoid direct sunlight, high temperature, and high humidity.
Protect against moisture, contamination, and physical damages.

XI.    TOXICITY DATA:

ACUTE ORAL TOXICITY: Oral LD50:2000mg/kg or more (Rat)

XII.   OTHER INFORMATION:

The information presented herein is based on data considered to be
Accurate as of the date of preparation of this Material Safety Data
Sheet. However, the accuracy or completeness of this information and
recommendations or suggestions are made without warranty or guarantee.
Since the conditions of use are beyond the control of Marine Bio
Co., Ltd., it is the responsibility of the user to determine the
conditions of safe use.

■ NON-CALCINATED CORAL CALCIUM MANUFACTURING PROCESS

Raw Materials Fukashisuna (Desalted Weathered Reef Building Coral Sand) / Inspection for Acceptance
Washing Dehydration Wash and excluding foreign material
Drying Sterilization Dryer (Heat drying & sterilizaion/abt. 200℃/more than 10 min.)
Sieving Vibrating sieve (excluding foreign materials/magnetic metal remover)
Pulverizing at room temperature
Packing 20Kg polyvinyl container in Kraft 3 tiers film bag/stored on the palette tied with stretch
Inspection
Storage Stored in warehouse at room temperature
Shipping at room temperature

Manufacturer : Marine Bio Co.,Ltd.
Standard:Particle size : 44 microns pass 90% or more Dry Loss in weight ; less than 1%
Limit of test time : Within 7 days after manufactured
Tester  : QC
Approver : Plant Manager